Table of Contents |
---|
Specifications
Make | Bosch |
---|---|
Model | B22CT80SNS01 |
Refrigerator Capacity | 16.27 Cu. Ft. |
Freezer Capacity | 5.52 Cu. Ft. |
Total Capacity | 21.8 Cu. Ft. |
Width | 35 5/8 Inch |
Depth | 30 1/8 Inch |
Height | 71 7/8 Inch |
No. of Shelves | 5 |
Gallon Door Storage | Yes |
Water Dispenser | Internal |
Ice Maker | Yes |
Other Features |
|
Pictures
Setup
Temperature Calibration
Compartment | Display Temp F/C | Actual Temp F/C |
---|---|---|
Fridge | 5 7 | 3 5 |
Freezer |
Based on above, the fridge temperature was calibrated. Increased temperature reading by 3°F.
Service Test - 211 Fresh Food Temperature Adjustment
Press the Refrigerator Temperature UP +/ Keypad or Refrigerator DOWN -/ Keypad to change calibration of Fresh Food Temperature plus or minus 1°F increments up to 6°F.
Levelling the Doors
Having the doors just right is important since it will ensure that the doors close properly.
From the front to the back, there should be a 1/4 inch difference in levelness (higher in the front)... Adjust by the two adjuster foot pegs (front on floor).
Use a 1/4" socket and a ratchet to turn the adjuster foot pegs screws until the tops of the french doors are even with each other.
To adjust the doors:
- Remove the grill
- Adjust the two adjuster foot pegs using a 1/4" bolt driver. Check for level.
- Ensure Doors at top of fridge are even with each other and door closed properly and door's hinge flap is operating correctly.
Problems
Freezer is Cold but Refrigerator is Warm
Things to check (Top 6):
- Dirty Condenser Coils
- Malfunctioning Condenser Fan Motor
- Defective Evaporator Fan Motor
- Faulty Start Relay or Capacitor
- Evaporator Frosted Over
- Malfunctioning Temperature Control Board
Round 1
Observations
- Freezer is at temp(0F) but fridge is warm(57F).
Actions
- Checked the condenser fan and it didn't appear to be running.
- Removed and tested it by applying 120v to the fan contacts. Seems to work fine.
- Replaced and it has been working fine since.
Questions
- Is the fan working intermittently?
- Could there be a thermostat/control issue?
- Is it possible the door was not closing properly and the french door's door flap was not engaged?
Round 2
It Happened Again
- Checked condenser fan and it was working.
- Not the door flap
- Cycled the power and no change
- Turned off for 30-60 minutes and it started up and cooled!
- Could be:
- damper freezing closed due to bad fridge temp calibration
- defroster
- defrost timer
- damper stuck
- evaporator fan? (heard it, so unlikely unless the fan blades are messed up)
Current Thought
I think the temp was getting too cold in the fridge compartment causing the damper to freeze closed. Temperature displayed on fridge was 3F higher than actual. Setting the temp to 38F was equivalent to 35F(1.6C). Fridge was probably dipping below zero from time to time.
Fridge temperature was calibrated. We shall see if it happens again.
Ice Maker Repair
The ice make arm was missing so I made a new one... Time will tell if it works.
Who really makes the ice maker?
Observations
- part number on Bosch supplied ice maker is W10683115 (Whirlpool)
- Apparently W10683115 was replaced with W10886931.
- W10886931 Parts Breakdown - https://www.reliableparts.ca/lookup/237899/1612272#diagram
- Arm: W11559683 ~ $54
I successfully replaced the arm with this part:
Wirlpool WP67004028 - Amazon ~$20
Parts
https://www.partselect.ca/Models/B22CT80SNS/?retfrus=1
IceMaker
# | Mfr Part# | Image | Description |
---|---|---|---|
818 | 00798550 | IceMaker Arm reliableparts.ca ~$93 (Way too expensive!) partselect.ca ~$106 Whirlpool ? W11559683 ~ $54 Wirlpool WP67004028 - Works! Amazon ~$20 | |
- | - | Could a arm from another brand work?? Ordered this one: WORKS!!! Wirlpool WP67004028 Ice Maker Shut-Off Arm Amazon ~$20 | |
825 | 00798555 | reliableparts.ca - $212 partselect.ca - $243 Whirlpool W10683115 |
Freezer
# | Mfr Part# | Image | Description |
---|---|---|---|
231 | 00798455 | Evaporator Motor Fan |
Fridge Assembly
# | Mfr Part# | Image | Description |
---|---|---|---|
314 | 00798467 | Control Unit (Damper Control Motor Assembly) reliableparts.ca ~$359 Whirlpool Part: reliableparts.ca ~$180 | |
303 | 12004484 | Water Filter |
Compressor
# | Mfr Part# | Image | Description |
---|---|---|---|
508 | 00631840 | Whirlpool W11123104 Condenser Fan Motor Panasonic Fdqr107wd Bosch Part reliableparts.ca ~ $430 Whirlpool Part reliableparts.ca ~ $105 115V - 60Hz | |
533 | 00798480 | Defrost Heater | |
540 | 00713453 | Evaporator Coil |
Shelf/Rack Assembly
# | Mfr Part# | Image | Description |
---|---|---|---|
631 | 00798539 | Ice Scoop L: 22cm / ~9 in W: 9cm / ~ 3.5 in Replaced with: Berglander Stainless Steel Ice Scoop 6 OZ / amazon.ca |
Service Test
The service test functions are performed using the refrigerator display and keypad.
Enter Service Test Mode by performing the following sequence of events:
- Press and hold the Door Alarm Keypad.
- Press and hold the Refrigerator Temperature UP / +Keypad.
- Release the Door Alarm Keypad and wait 3 seconds.
- The Freezer display wil display SE confirming entry in the Service Mode.
- Press the Refrigerator Temperature UP +/ Keypad again to confirm entry in the Service Mode.
- Display wil show 101 in the left display and numeric or dashes in right display.
- Press Freezer Refrigerator Temperature UP / +Keypad and Freezer DOWN /-Keypad ot toggle through Service Test numbers.
- To exit service test mode, open and close refrigerator door or hold door alarm for 3 seconds.
See technicianServiceManual.pdf for service test details.
References
Reference | URL |
---|---|
User Manual | |
Technician Manual | |
Schematic | |
Wiring Diagram |